Massive clean green electricity plant to be officially launched in Northern Cape this month
Spanish multinational Abengoa will officially launch its third large-scale solar thermal plant in South Africa on May 18, near Pofadder in the Northern Cape. It is expected to have an impact on the local community and demonstrate the viability of renewable energy as a sustainable source of electricity.
The parabolic thermal installation, Xina Solar One, has a total installed capacity of 100MW and follows the launch of KaXu and Khi, making it the largest such system in Africa.
“Khi, KaXu and Xina Solar One, all together, reach an installed capacity of 250MW of renewable and dispatchable energy, offset 831 000 tons of CO2 emissions every year and supply upward of 220 000 homes,” Dominic Goncalves, vice-president of business development at Abengoa South Africa told News24.
He said that the project delivered 1 800 jobs during the construction phase and is expected to create 80 permanent jobs during the operational phase over the next 20 years.
“Our commitment, after achieving the practical completion of the plant, is to employ 70% South African people, although we are focusing on reaching 100%,” said Goncalves.
Electricity after sunset
Solar thermal plants such as Xina Solar One typically use a set of parabolic mirrors to reflect the sun’s rays to a central tower hub which contains a salt.
Under the extreme heat, the salt melts and this is in turn used to heat water and the steam from the water is used to turn a turbine, creating electricity
Unlike solar photovoltaic (PV) systems, the thermal plants, also known as concentrated solar plants (CSPs), are able to continue producing electricity even after the sun sets because the molten salt remains hot for hours.
“The efficiency of CSP plants is typically exceeding that of commercial PV installations notably. A direct comparison between those technologies is possible as both make use of the same resource, solar irradiation,” Dr Matti Lubkoll, who teaches solar thermal energy at Stellenbosch University told News24.
“Wind turbines tend to have a higher efficiency in terms of converting energy available in the wind into electric power,” he added.
According to the International Renewable Energy Agency (Irena), the levelised cost of electricity from CSPs is higher than PV or wind systems, though the agency was careful to point out that in high sunlight areas, the costs could be significantly less.
“In the years since all renewable energy technologies made significant progress and in 2017 CSP bids elsewhere in the world showed first tariffs below R1/kWh. This indicates that a time has been reached where a renewable energy technology with base-load capability can produce electricity at lower cost than conventional base-load,” said Lubkoll
He said that winning bids for wind power in South Africa came in at “R0.62/kWh and the winning CSP bid at R2.02 per kWh”, comparative to coal at R1.03/kWh in November 2015.
CSP technology is still a relatively new technology in clean energy production, and the EU-inspired Desertec initiative has so far failed to get off the ground.
The project had aimed to place CSP plants in the Sahara Desert and to export electricity to Europe and create jobs in northern African countries.
Irena’s Renewable Energy Technology: Cost Analysis Series on Concentrated Solar Power report says that globally, renewable energy projects need to be scaled up six times to meet climate goals set out in the Paris Agreement on climate change.
The agency, however, calculates that CSP will make up just 4% of renewable electricity generation compared to 22% from PV and 36% from wind by 2050.
“As deployment of CSP technologies increased maturity follows. Increased deployment will result in component cost reduction and increased maturity in reduced cost of financing, both significantly enabling cost reduction for electricity production cost of CSP,” Lubkoll said.
A key challenge for developing CSPs is the state of the transmission network and Lubkoll highlighted the contrast of the location of projects and the availability of transmission lines.
“In South Africa the best solar resource for CSP plants (actually among the best in the world, second only to the Atacama Desert in Chile) can be found in the Northern Cape around Upington. The specific location of CSP plants in this region therefore has to consider the availability of electricity transmission infrastructure.”
Energy Minister Jeff Radebe recently signed a R56bn contract with 27 independent power producers, but Goncalves insisted that the contract was not related to the launch of the Xina Solar One project.
He said the “practical completion” of Xina Solar One was in August 2017, meaning that the plant had been working at full capacity for the past eight months.
“We have been looking for the most appropriate date to celebrate an official launch considering agendas, climatology, etc,” said Goncalves.